膜科学与技术

草鱼养殖模拟废水正渗透处理工艺参数优化及膜污染特征研究

作者：杜江辉，蔡雨嫣，雷泽宇，许裕良，韩志英

单位： 1.浙江大学生物系统工程与食品科学学院，浙江杭州 310058；2.农业农村部设施农业装备与信息化重点实验室，浙江杭州 310058

关键词：正渗透；COD浓度；水通量；响应面法；膜污染

出版年,卷(期):页码： 2021,41(5):121-129

摘要：

本试验选用蔗糖溶液作汲取液，草鱼养殖模拟废水为原料液，采用响应面法研究不同汲取液浓度、错流过滤流速和汲取液温度下，正渗透系统原料液COD浓度和平均水通量的变化，研究汲取液浓度、错流过滤流速和汲取液温度相互作用，确定的最优工艺参数，并在最优工艺条件下考察正渗透膜污染特性。本研究试验结果表明，汲取液浓度和错流过滤流速对系统运行效果影响较大，温度影响次之，正渗透处理草鱼养殖模拟废水最优工艺参数组合为汲取液浓度2mol/L，错流过滤流速18.7cm/s，汲取液水温33.6℃，在此条件下草鱼模拟养殖废水COD浓度变化倍数为2.9，平均水通量27.4L/(m2?h)。正渗透膜表面污染物以蛋白质等有机污染物为主，还有少量的无机盐类物质。

In this study, sucrose solution was used as the draw solution of the forward osmosis system, and the simulated grass carp farming wastewater was used as the feed solution. By using the response surface method, the COD concentration of the feed solution and the average water flux of the system were investigated under different concentrations of draw solution, the flow rate of the cross-flow filtration and temperature of draw solution, consequently, the optimal parameters combination for the maximal values of COD concentration and the average water flux was determined. In addition, the membrane fouling in the forward osmosis system was characterized in this study. Results show that the concentration of the draw solution, the flow rate of the cross-flow filtration and the temperature of the draw solution had significant impacts on the COD concentration of the feed solution and the average water flux of the system, respectively. The concentration of the draw solution and the flow rate of the cross-flow filtration had greater impacts on the forward osmosis system, than the temperature of the draw solution did. The optimal combination of process parameters is as follows: the concentration of the draw solution is 2 mol/L, the flow rate of cross-flow filtration is 18.7 cm/s, and the temperature of the draw solution is 33.6 ℃. Under the forementioned optimal combination of process parameters conditions, the COD concentration multiple of the simulated wastewater is 2.9 and the average water flux is 27.4 L/(m2?h). The characterization of membrane fouling demonstrated that the pollutants attached on the membrane are mainly organic pollutants such as proteins, and inorganic salts were also detected.

杜江辉（1995-），男，硕士研究生，主要研究方向：养殖废水深度处理技术

参考文献：

[1]张昊.江西省草鱼养殖现状分析[D].江西：江西农业大学,2017.
[2]侯和菊.如何正确选择与使用鱼饲料[J].兽药与饲料添加剂,2009,14(02):39-40.
[3]王黎颖.小球藻对水产养殖废水的净化及响应[D].天津：天津科技大学,2018.
[4]朱先征.正渗透废水资源化技术及膜污染机制研究[D].上海:华东师范大学, 2017.
[5]Francis L, Ogunbiyi O, Saththasivam J, et al. A comprehensive review of forward osmosis and niche applications [J]. Environmental Science-water Research & Technology,2020, 6:1986-2015.
[6]Huang M H, Meng L J, Li B B, et al. Fabrication of innovative forward osmosis membranes via multilayered interfacial polymerization on electrospun nanofibers[J].Journal of Applied Polymer Science,2019,136(12):47247.
[7]Zhang C C, Huang M H, Meng L J, et al. Electrospun polysulfone (PSF)/titanium dioxide (TiO2) nanocomposite fibers as substrates to prepare thin film forward osmosis membranes[J]. Journal of Chemical Technology and Biotechnology,2017,92:2090-2097.
[8]Wang J L, Liu X J. Forward osmosis technology for water treatment: Recent advances and future perspectives[J].Journal of Cleaner Production,2021,280(P1):124354.
[9]Ibrar I, Altaee A, Zhou J L, et al. Challenges and potentials of forward osmosis process in the treatment of wastewater[J]. Critical reviews in Environmental Science and Technology, 2019,50(13):1339-1383.
[10]周根根．两种不同投喂营养源对主养草鱼池塘营养循环与能量转化效率的影响[D]．武汉:华中农业大学,2016.
[11]陈红雕,赵丹丹,杨浩,等.咸淡水集约化草鱼池塘饲料投喂量与水质及浮游生物的关系[J/OL].华中农业大学学报:1-10[2021-04-21].http://kns.cnki.net/kcms/detail/42.1181.S.20201223.1401.016.html.
[12]李亚宁,郝亚超,李亮,等.响应曲面法优化纳滤去除废水中重金属离子的研究[J].膜科学与技术,2020,40(06):111-117.
[13]胡斌. 正渗透技术从非常规水源中汲取净水用于农业种植研究[D].浙江:浙江大学,2019.
[14]白洋. 海水作为汲取液的正渗透浓缩污水效能研究[D].哈尔滨:哈尔滨工业大学,2015.
[15]Yan S, Jia Y T, Li M S, et al. Dynamic changes of the fouling layer in forward osmosis based membrane processes for municipal[J]. Wastewater Treatment, 2018, 549:523-532.
[16]Mi B X, Menachem E. Chemical and physical aspects of organic fouling of forward osmosis membranes[J]. Journal of Membrane Science,2008,320:292-302.
[17]Xia L L, Andersen M F, Hélix-Nielsen C, et al. Novel commercial aquaporin flat-sheet membrane for forward osmosis[J].Industrial & Engineering Chemistry Research,2017:11919-11925.
[18]方舟,高悦,梁鹏，等.正渗透膜浓缩生活污水效果及膜过程特性[J].中国给水排水,2015,31(05):40-44.
[19]Zhao P, Gao B, Xu S, et al. Polyelectrolyte-promoted forward osmosis process for dye wastewater treatment-Exploring the feasibility of using polyacrylamide as draw solute[J]. Chemical Engineering Journal,2015,264:32-38.
[20]Wang C, Li Y M, Wang Y Q. Treatment of greywater by forward osmosis technology: role of the operating temperature[J]. 2019, 40(26):3434-3443.
[21]Tao S, Yang Y, Long N. Response surface method to study the effect of conical surface and vortex-finder lengths on de-foulant hydrocyclone with reflux ejector[J]. Separation and Purification Technology, 2020, 253:117511.
[22]Tian H F, Wang J, Pei J, et al. High Spatiotemporal Resolution Mapping of Surface Water in the Southwest Poyang Lake and Its Responses to Climate Oscillations[J]. Sensors, 2020, 20(17):4872.
[23]Zaroual Z, Chaair H, Essadki A H, et al. Optimizing the removal of trivalent chromium by electrocoagulation using experimental design[J]. Chemical Engineering Journal,2009, 148(2):488-495.
[24]林孝昶. 猪场沼液镁阳极双室电解除磷工艺研究[D].浙江:浙江大学,2018.
[25]Kanjanapa E, Jirarat A. Optimization of High-Protein Glutinous Rice Flour Production Using Response Surface Method[J]. Rice Science,2020,27(01):75-80.
[26]Mi B, Elimelech M. Organic fouling of forward osmosis membranes: Fouling reversibility and cleaning without chemical reagents[J]. Journal of Membrane Science,2010,348(1-2):337-345.
[27]Francesco R, Giagnorio M, Zodrow K R, et al. Organic fouling in forward osmosis: governing factors and a direct comparison with membrane filtration driven by hydraulic pressure[J]. Journal of Membrane Science, 2021, 619:118759.
[28]Choudhury M R, Anwar N, Jassby D, et al. Fouling and wetting in the membrane distillation driven wastewater reclamation process – a review[J]. Journal of Colloid and Interface Science, 2019, 269:370-399.
[29]Andreeva M A, Gil V V, Pismenskaya N D, et al. Effect of homogenization and hydrophobization of a cation-exchange membrane surface on its scaling in the presence of calcium and magnesium chlorides during electrodialysis[J]. Journal of Membrane Science. 2017, 540:183-191.
[30]Nguyen A, Azari S, Zou L. Coating zwitterionic amino acid 1-DOPA to increase fouling resistance of forward osmosis membrane[J]. Desalination, 2013,312:82-87.
[31]王雷.猪场沼液化学絮凝/电絮凝—纳滤膜浓缩工艺研究[D].浙江：浙江大学,2016.
[32]刘约权.现代仪器分析[M]. 北京：高等教育出版社,2006:92.
[33]Zhuang H F, Han H J, Jia S Y, et al. Advanced treatment of biologically pretreated coal gasification wastewater using a novel anoxic moving bed biofilm reactor (ANMBBR)-biological aerated filter (BAF) system[J].Bioresource Technology,2014,157:223-230.
[34]李琨.纳滤分离煤化工浓盐水的效能及膜污染机理研究[D].哈尔滨:哈尔滨工业大学,2020.
[35]Zvi S, Hanna R, Yoram O, et al. Effect of surface-exposed chemical groups on calcium-phosphate mineralization in water-treatment systems[J]. Environmental Science&Technology,2010,44:7937-7943.
[36]孙燕.正渗透处理城市污水的膜污染特性及控制研究[D].哈尔滨：哈尔滨工业大学,2019.
[37]Liu T Y, Liu Z H, Zhang R X, et al. Fabrication of a thin film nanocomposite hollow fiber nanofiltration membrane for wastewater treatment[J]. Journal of Membrane Science,2015,488:92-102.

服务与反馈：

【文章下载】【加入收藏】

《膜科学与技术》编辑部地址：北京市朝阳区北三环东路19号蓝星大厦邮政编码：100029 电话：010-64426130/64433466 传真：010-80485372邮箱：mkxyjs@163.com