膜科学与技术

添加聚合物中间层对NaA分子筛膜的合成与性能的影响

作者：赖露露，邵佳，王正宝

单位：浙江大学化学工程与生物工程学系，浙江大学膜与水处理技术教育部工程研究中心，杭州 310027

关键词： NaA分子筛膜；PVP中间层；通量

出版年,卷(期):页码： 2013,33(3):49-53

摘要：

采用浸涂法涂敷晶种，并通过二次生长法在α-Al2O3中空纤维外壁制备了NaA分子筛膜，考察了添加聚乙烯吡咯烷酮（PVP）中间层对成膜和膜分离性能的影响. 采用SEM对膜的表面形貌进行表征，通过75 ℃渗透汽化分离90 wt.%的乙醇/水溶液表征膜层的分离性能. 研究发现采用浸涂法涂敷晶种，无PVP中间层制备的膜层对乙醇/水溶液的分离因子仅为3000左右，而添加了PVP中间层制备的膜层的分离因子可超过10000. 考察了PVP添加量对膜通量的影响. 研究发现添加了PVP中间层制备的膜（分离因子> 10000）的通量比无PVP中间层的膜（浸涂-滚擦法涂敷晶种，分离因子> 10000）的通量（7.83 kg•m-2•h-1）低，且随着制备中间层的PVP溶液浓度的升高，膜的通量相应降低，当PVP浓度分别为1 %，3%和5%时，膜的通量分别为7.35，5.82和5.51 kg•m-2•h-1.

Zeolite NaA membranes were prepared on the outer surface of α-Al2O3 hollow fiber supports by secondary growth method. Dip-coating was used as seeding method. The influences of adding polyvinyl pyrrolidine (PVP) intermediate layer on membrane formation and its separation properties were investigated. The synthesized membranes were characterized by scanning electron microscopy (SEM). And the separation properties of the membranes were evaluated by pervaporation of 90 wt.% ethanol/water mixture at 75 oC. It is shown that the zeolite membrane prepared without PVP coating has a separation factor around 3000 while the membrane prepared with PVP coating has a separation factor higher than 10000 by using the dip-coating seeding method. The effect of the PVP coating amount on the flux of the as-synthesized membranes was also investigated. The membranes synthesized with PVP coatings (the separation factor was > 10000) had a lower flux compared to those synthesized without PVP coatings (Dipcoating-wiping seeding method, the separation factor was > 10000) (7.83 kg•m-2•h-1). With increasing the concentration of the PVP aqueous solution, the fluxes of the zeolite membranes correspondingly decreased, i.e., the fluxes were 7.35, 5.82 and 5.51 kg•m-2•h-1 with PVP concentration of 1 .%, 3t% and 5% respectively.

赖露露（1987-），女，福建人，在读硕士，从事NaA型分子筛膜的合成技术，*通讯联系人，E-mail: zbwang@zju.edu.cn

参考文献：

[1] Xu X C，Yang W S，Liu J，Lin L W. Synthesis and perfection evaluation of NaA zeolite membrane [J]. Sep Purif Technol，2001，25（1-3）：475～485.
[2] Hedlund J，Scheoman B，Sterte J. Ultrathin oriented zeolite LTA films [J]. Chem Commun，1997，（13）：1193～1194.
[3] Huang A S，Liang F Y，Steinbach F，Caro J. Preparation and separation properties of LTA membranes by using 3-aminopropyltriethoxysilane as covalent linker [J]. J Membr Sci，2010，350（1-2）：5～9.
[4] Huang A S，Caro J. Cationic polymer used to capture zeolite precursor particles for the facile synthesis of oriented zeolite LTA molecular sieve membrane [J]. Chem Mater，2010，22（15）：4353～4355.
[5] Naskar M K，Kundu D，Chatterjee M. Influence of PVP buffer layer on the formation of NaA zeolite membrane [J]. J Porous Mater，2011，18（3）319～327.
[6] Wang Z B，Ge Q Q，Shao J，Yan Y S. High performance zeolite LTA pervaporation membranes on ceramic hollow fibers by dipcoating-wiping seed deposition [J]. J Am Chem Soc，2009，131（20）6910～6911.
[7] Shao J，Ge Q Q，Shan L J，Wang Z B，Yan Y S. Influences of seeds on the properties of zeolite NaA membranes on alumina hollow fibers [J]. Ind Eng Chem Res，2011，50（16）9718～9726.
[8] 李邦民，吕丹，王金渠，鲍仲英，殷德宏. 在α-Al2O3陶瓷管内表面动态合成NaA分子筛膜 [J]. 膜科学与技术，2005，25（6）21～23.
[9] Ge Q Q，Shao J，Wang Z B，Yan Y S. Effects of the synthesis hydrogel on the formation of zeolite LTA membranes [J]. Micropor Mesopor Mater，2012，151（1）303～310.
[10] Pera-Titus M，Mallada R，Llorens J，Cunill F，Santamaria J. Preparation of inner-side tubular zeolite NaA membranes in a semi-continuous synthesis system [J]. J Membr Sci，2006，278（1-2）401～409.

服务与反馈：

【文章下载】【加入收藏】

《膜科学与技术》编辑部地址：北京市朝阳区北三环东路19号蓝星大厦邮政编码：100029 电话：010-64426130/64433466 传真：010-80485372邮箱：mkxyjs@163.com